Issue

Vol. 35 No. 2 (2023): Vol 35 Issue 2, 2023

Copyright (c) 2023 AJC

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

Role of Chemical based Inhibitors in Protecting the Concrete Structures from Corrosion: Present Status and Future Prospects: A Review

https://doi.org/10.14233/ajchem.2023.26883
Clementz Edwardraj Freeda Christy
Department of Civil Engineering, School of Mechanical, Auto, Aero and Civil Engineering, Kalasalingam Academy of Research and Education (Deemed to be University), Anand Nagar, Krishnankoil-626126, India
Arputharaj Samson Nesaraj
Department of Chemistry, School of Advanced Sciences, Kalasalingam Academy of Research and Education (Deemed to be University), Anand Nagar, Krishnankoil-626126, India

Corresponding Author(s) : Arputharaj Samson Nesaraj

samson@klu.ac.in

Asian Journal of Chemistry, Vol. 35 No. 2 (2023): Vol 35 Issue 2, 2023

Abstract

Building industry is a rapid growing worldwide because of urbanization. Concrete is a primary requirement in the construction of residential buildings, shopping malls, industry structures, etc. The life of a building mainly depends on the ingredients used in the concrete during the construction activity. However, the concrete structures undergo deterioration because of the presence of highly corrosive ions in the admixture after long term. If the corrosion of the steel rods is severe in concrete, the buildings may collapse at any time which will lead to heavy loss for human lives. In this regard, protection of steel embedded in concrete from the corrosive attack is an important issue among civil engineering professionals and chemists. For this purpose, the technologies related to the adoption of suitable composition of steel, suitable combination of ingredients in the concrete, change of processing parameters/methodologies, etc. are being worked out. Apart from this, suitable chemical inhibitors are being studied across the globe to overcome this corrosion problem in a greater extent. In this review article, the type of chemical inhibitors used in admixtures and their effective role in protecting the concrete structures are discussed. Based on this, suitable suggestions are also recommended for the benefit of the society.

Keywords

Concrete structures Concrete structures Corrosion Corrosion Failure of buildings Failure of buildings Chemical inhibitors Chemical inhibitors Protection of steel Protection of steel
Edwardraj Freeda Christy, C., & Samson Nesaraj, A. (2023). Role of Chemical based Inhibitors in Protecting the Concrete Structures from Corrosion: Present Status and Future Prospects: A Review. Asian Journal of Chemistry, 35(2), 247–253. https://doi.org/10.14233/ajchem.2023.26883
Download Citation
Endnote/Zotero/Mendeley (RIS)
BibTeX
References
  1. T. Gunawardena and P. Mendis, Encyclopedia, 2, 70 (2022); https://doi.org/10.3390/encyclopedia2010006
  2. H.S. Link and R.J. Schmitt, Ind. Eng. Chem., 53, 590 (1961); https://doi.org/10.1021/ie50619a036
  3. C. Bartlett, Nexus Netw. J., 16, 299 (2014); https://doi.org/10.1007/s00004-014-0193-9
  4. H. Higashiyama, K. Yamauchi, M. Sappakittipakorn, M. Sano and O. Takahashi, Constr. Build. Mater., 40, 1021 (2013); https://doi.org/10.1016/j.conbuildmat.2012.11.078
  5. Y. Pawar and S. Kate, Int. Res. J. Eng. Technol., 7, 1820 (2020).
  6. X. Xian, D. Zhang and Y. Shao, J. Clean. Prod., 313, 127943 (2021); https://doi.org/10.1016/j.jclepro.2021.127943
  7. F. Zhang, X. Xi and S. Yang, Corros. Mater. Degrad., 2, 641 (2021); https://doi.org/10.3390/cmd2040034
  8. Y. Sumra, S. Payam and I. Zainah, J. Wuhan Univ. Technol.-Mater. Sci. Educ., 35, 908 (2020); https://doi.org/10.1007/s11595-020-2337-y
  9. A. James, E. Bazarchi, A.A. Chiniforush, P. Panjebashi Aghdam, M.R. Hosseini, A. Akbarnezhad, I. Martek and F. Ghodoosi, Constr. Build. Mater., 224, 1026 (2019); https://doi.org/10.1016/j.conbuildmat.2019.07.250
  10. L. Zhang, D. Niu, B. Wen and D. Luo, Materials, 12, 4245 (2019); https://doi.org/10.3390/ma12244245
  11. Y.S. Choi, S.-T. Yi, M.Y. Kim, W.Y. Jung and E.I. Yang, Constr. Build. Mater., 54, 180 (2014); https://doi.org/10.1016/j.conbuildmat.2013.12.065
  12. F.J. Olguin Coca, M.U. Loya Tello, C. Gaona-Tiburcio, J.A. Romero and A. Martínez-Villafañe, Int. J. Electrochem. Sci., 6, 3438 (2011).
  13. M. Kaushal and G. Singh, Int. J. Innov. Res. Sci. Eng. Technol., 9, 11311 (2020).
  14. A. Shakya and M.U. Rizvi, Int. Res. J. Eng. Technol., 8, 336 (2021).
  15. J. Ress, U. Martin, J. Bosch and D.M. Bastidas, Coatings, 11, 113 (2021); https://doi.org/10.3390/coatings11020113
  16. H.Z. López-Calvo, P. Montes-Garcia, I. Kondratova, T.W. Bremner and M.D.A. Thomas, Mater. Corros., 64, 599 (2013); https://doi.org/10.1002/maco.201106319
  17. G.K. Al-Chaar, M. Alkadi and P.G. Asteris, Open Constr. Build. Technol. J., 7, 33 (2013); https://doi.org/10.2174/1874836801307010033
  18. N. Sharma and P. Sharma, IOP Conf. Series Mater. Sci. Eng., 1116, 012175 (2021); https://doi.org/10.1088/1757-899X/1116/1/012175
  19. L. Dembovska, D. Bajare, I. Pundiene and L. Vitola, Procedia Eng., 172, 202 (2017); https://doi.org/10.1016/j.proeng.2017.02.050
  20. R.B. Polder and H. de Vries, Heron, 46, 227 (2001).
  21. N. Gartner, T. Kosec and A. Legat, Materials, 13, 407 (2020); https://doi.org/10.3390/ma13020407
  22. D.V. Val and M.G. Stewart, Struct. Saf., 25, 343 (2003); https://doi.org/10.1016/S0167-4730(03)00014-6
  23. I.B. Topçu and A. Uzunömeroglu, J. Struct. Eng. Appl. Mechanics, 3, 93 (2020); https://doi.org/10.31462/jseam.2020.02093109
  24. K.T. Kim, H.W. Kim, H.Y. Chang, B.T. Lim, H.B. Park and Y.S. Kim, Adv. Mater. Sci. Eng., 2015, 408138 (2015); https://doi.org/10.1155/2015/408138
  25. T.D. Marcotte and C.M. Hansson, Mater. Struct., 40, 325 (2007); https://doi.org/10.1617/s11527-006-9170-4
  26. M.A. Quraishi, D.K. Nayak, R. Kumar and V. Kumar, J. Steel Struct. Construct., 3, 1000124 (2017); https://doi.org/10.4172/2472-0437.1000124
  27. A. Fahrizal and T. Al-Ghareeb, Mod. Concepts Mater. Sci., 4(5) (2021); https://doi.org/10.33552/MCMS.2021.04.000594
  28. J.M. Gaidis, Cement Concr. Compos., 26, 181 (2004); https://doi.org/10.1016/S0958-9465(03)00037-4
  29. S. Marzorati, L. Verotta and S.P. Trasatti, Molecules, 24, 48 (2018); https://doi.org/10.3390/molecules24010048
  30. K.Y. Ann, H.S. Jung, H.S. Kim, S.S. Kim and H.Y. Moon, Cement Concr. Res., 36, 530 (2006); https://doi.org/10.1016/j.cemconres.2005.09.003
  31. Y. Song, J. Liu, H. Wang and H. Shu, Int. J. Corros., 2019, 3060869 (2019); https://doi.org/10.1155/2019/3060869
  32. V.L. Satish and V. Ravindra, IOP Conf. Series Mater. Sci. Eng., 1025, 012002 (2021); https://doi.org/10.1088/1757-899X/1025/1/012002
  33. J.M. Gaidis, J.T. Lundquist and A.M. Rosenberg, Mater. Perform., 18, 36 (1979).
  34. L. Jinsong, G. Qian, L. Jing and F. Lin, Int. J. Electrochem. Sci., 17, 22027 (2022); https://doi.org/10.20964/2022.02.35
  35. A.M. Alshamsi and A.H. Bushlaibi, Eng. J. Univ. Qatar, 13, 97 (2000).
  36. M. Devi, Int. J. Eng. Sci., 2, 23 (2013).
  37. B. Sangoju, B.H. Bharatkumar, P. Srinivasan, K. Ramanjaneyulu, R. Gettu and N.R. Iyer, J. Sci. Ind. Res., 74, 82 (2015).
  38. K.K. Sideris and A.E. Savva, Cement Concr. Compos., 27, 277 (2005); https://doi.org/10.1016/j.cemconcomp.2004.02.016
  39. M. Afrin and P. Kuldeep, Int. J. Eng. Develop. Res., 7, 273 (2019).
  40. J. Sørensen and L. Thorling, Geochim. Cosmochim. Acta, 55, 1289 (1991); https://doi.org/10.1016/0016-7037(91)90307-Q
  41. R. Dharmaraj and R. Malathy, Indian J. Sci. Technol., 8, 1 (2015); https://doi.org/10.17485/ijst/2015/v8i36/87647
  42. N.S. Teklegiorgis, B. Pradhan, J.K. Prusty and J.K. Das, J. Mater. Civ. Eng., 34, 04022007 (2022); https://doi.org/10.1061/(ASCE)MT.1943-5533.0004139
  43. V. Madhavan and C. Antony Jeyasehar, APRN Int. J. Eng. Appl. Sci., 5, 11 (2013).
  44. B.P. Maliekkal, J.T. Kakkassery and V.R. Palayoor, Int. J. Ind. Chem., 9, 105 (2018); https://doi.org/10.1007/s40090-018-0142-7
  45. M. Pandiarajan, S. Rajendran, J.S. Bama and R.J. Rathish, J. Chem. Pharm. Res., 7(10S), 120 (2015).
  46. G. Kilinççeker and N. Yesilyurt, Nat. Eng. Sci., 3, 87 (2018).
  47. X.-P. Wang, R.-G. Du, Y.-F. Zhu, Y. Guo, W. Chen, Z.-Y. Yang, S.-G. Dong and C.-J. Lin, ECS Trans., 50, 43 (2013); https://doi.org/10.1149/05050.0043ecst
  48. H. Hazehara, D.N. Katpady, M. Soeda, Y. Okabe and K. Era, Constr. Build. Mater., 264, 120586 (2020); https://doi.org/10.1016/j.conbuildmat.2020.120586
  49. H.-S. Lee and S.-W. Shin, Constr. Build. Mater., 21, 1 (2007); https://doi.org/10.1016/j.conbuildmat.2006.01.004
  50. K. Kobayashi and Y. Takagi, Cement Concr. Compos., 114, 103709 (2020); https://doi.org/10.1016/j.cemconcomp.2020.103709
  51. H.-S. Lee, H.-S. Ryu, W.-J. Park and M.A. Ismail, Materials, 8, 251 (2015); https://doi.org/10.3390/ma8010251
  52. V.T. Ngala, C.L. Page and M.M. Page, Corros. Sci., 45, 1523 (2003); https://doi.org/10.1016/S0010-938X(02)00248-2
  53. C. Alonso, C. Andrade, C. Argiz and B. Malric, Cement Concr. Res., 26, 405 (1996); https://doi.org/10.1016/S0008-8846(96)85028-9
  54. T. Chaussadent, V. Nobel-Pujol, F. Farcas, I. Mabille and C. Fiaud, Cement Concr. Res., 36, 556 (2006); https://doi.org/10.1016/j.cemconres.2005.09.006
  55. D.M. Bastidas, M. Criado, V.M. La Iglesia, S. Fajardo, A. La Iglesia and J.M. Bastidas, Cement Concr. Compos., 43, 31 (2013); https://doi.org/10.1016/j.cemconcomp.2013.06.005
  56. F. Tittarelli, A. Mobili and T. Bellezze, IOP Conf. Series Mater. Sci. Eng., 225, 012106 (2017); https://doi.org/10.1088/1757-899X/225/1/012106
  57. A. Douche-Portanguen, W. Prince, B. Malric and G. Arliguie, Cement Concr. Res., 35, 1714 (2005); https://doi.org/10.1016/j.cemconres.2004.12.008
  58. O.S.I. Fayomi, A.P.I. Popoola and O.O. Joseph, Energy Procedia, 119, 883 (2017); https://doi.org/10.1016/j.egypro.2017.07.141
  59. O.A. Omotosho, J.O. Okeniyi and O.O. Ajayi, J. Fail. Anal. Prev., 10, 408 (2010); https://doi.org/10.1007/s11668-010-9375-2
  60. J.O. Okeniyi, O.A. Omotosho, O.O. Ajayi and C.A. Loto, Constr. Build. Mater., 50, 448 (2014); https://doi.org/10.1016/j.conbuildmat.2013.09.063
  61. M. Pandiarajan, S. Rajendran and R.J. Rathish, Res. J. Chem. Sci., 4, 49 (2014).
  62. C.A. Loto, O.A. Omotosho and A.P.I. Popoola, Int. J. Phys. Sci., 6, 2275 (2011).
  63. O.S.I. Fayomi, A.P.I. Popoola, T. Oloruntoba and A.A. Ayoola, Cogent Eng., 4, 1318736 (2017); https://doi.org/10.1080/23311916.2017.1318736
  64. O.A. Omotosho, C.A. Loto and O.O. Ajayi, Int. J. Electrochem. Sci., 9, 2171 (2014).
  65. S.M. Meshari, Basrah J. Sci., 30, 142 (2012).
  66. L. Chen, D. Lu and Y. Zhang, Materials, 15, 2023 (2022); https://doi.org/10.3390/ma15062023
  67. M. Osial and D. Wiliñski, J. Building Chem., 1, 42 (2016).
  68. C.K. Nmai, Cement Concr. Compos., 26, 199 (2004); https://doi.org/10.1016/S0958-9465(03)00039-8
  69. A. de Valle-Moreno, A. Torres-Acosta, M. Martínez-Madrid and J. Terán-Guillén, Superficies y Vacío, 23, 188 (2010).
  70. Y. Tong, J. Ye, Q. Wang, H. Zhang, H. Yu and A.-O. Seibou, J. Asian Archit. Build. Eng., (2022); https://doi.org/10.1080/13467581.2022.2046004
  71. M. Ormellese, L. Lazzari, S. Goidanich, G. Fumagalli and A. Brenna, Corros. Sci., 51, 2959 (2009); https://doi.org/10.1016/j.corsci.2009.08.018
  72. S.K. Ahmed, W.B. Ali and A.A. Khadom, Int. J. Ind. Chem., 10, 159 (2019); https://doi.org/10.1007/s40090-019-0181-8
  73. H.S. Ryu, C.G. Lim, T.W. Kang, S. Lim, H.T. Kim and S.H. Shin, Adv. Mater. Sci. Eng., 2019, 8294360 (2019); https://doi.org/10.1155/2019/8294360
  74. R.K. Rai, A.S. Trivedi and M. Sharma, IOSR J. Mech. Civ. Eng., 13, 48 (2016).
  75. T.A. Nguyen and X. Shi, Anti-Corros. Methods Mater., 56, 3 (2009); https://doi.org/10.1108/00035590910923400
  76. G. Batis, P. Pantazopoulou and A. Routoulas, Cement Concr. Compos., 25, 371 (2003); https://doi.org/10.1016/S0958-9465(02)00061-6
  77. F. Wombacher, U. Maeder and B. Marazzani, Cement Concr. Compos., 26, 209 (2004); https://doi.org/10.1016/S0958-9465(03)00040-4
  78. C. Xu, W.L. Jin, H.L. Wang, H.T. Wu, N. Huang, Z.Y. Li and J.H. Mao, Constr. Build. Mater., 115, 602 (2016); https://doi.org/10.1016/j.conbuildmat.2016.04.076
  79. K.K. Sagoe-Crentsil, V.T. Yilmaz and F.P. Glasser, Cement Concr. Res., 23, 1380 (1993); https://doi.org/10.1016/0008-8846(93)90075-K
  80. Y.I. Kuznetsov and G.V. Redkina, Coatings, 12, 149 (2022); https://doi.org/10.3390/coatings12020149
  81. B. Lin and Y. Zuo, RSC Adv., 9, 7065 (2019); https://doi.org/10.1039/C8RA10083G
  82. B. Bavarian, A.O. Alaba, L. Reiner and J. Meyer, Mater. Perform., 57, 20 (2018).
  83. H.-S. Ryu, D.-M. Kim, S.-H. Shin, W.-J. Park and S.-J. Kwon, Int. J. Concr. Struct. Mater., 12, 13 (2018); https://doi.org/10.1186/s40069-018-0243-x
  84. Q. Xu, H. Gao, J. Zeng, C. Chen, W. Zhou, S. Wang, X. Tian and Y. Peng, Can. J. Chem. Eng., 94, 1909 (2016); https://doi.org/10.1002/cjce.22571
  85. M. Cabrini, F. Fontana, S. Lorenzi, T. Pastore and S. Pellegrini, J. Chem., 2015, 521507 (2015); https://doi.org/10.1155/2015/521507
  86. A.S. Fazayel, M. Khorasani and A.A. Sarabi, Appl. Surf. Sci., 441, 895 (2018); https://doi.org/10.1016/j.apsusc.2018.02.012
  87. Y. Peng, A.E. Hughes, J.I. Mardel, G.B. Deacon, P.C. Junk, M. Forsyth, B.R.W. Hinton and A.E. Somers, ACS Appl. Mater. Interfaces, 11, 36154 (2019); https://doi.org/10.1021/acsami.9b13722
  88. Y.P. Asmara, T. Kurniawan, A.G.E. Sutjipto and J. Jafar, Indonesian J. Sci. Technol., 3, 158 (2018); https://doi.org/10.17509/ijost.v3i2.12760
  89. K. Kavya, S. Keerthana and T. Pradeep, Eds.: S.K. Shukla, B.B. Das, S. Chandrasekaran and S. Kolathayar, Effect of Green Corrosion Inhibitors on the Properties of Mortar and Concrete, In: Smart Technologies for Sustainable Development, Lecture Notes in Civil Engineering, Springer: Singapore, vol. 78 (2021). https://doi.org/10.1007/978-981-15-5001-0_34
  90. B. Valdez-Salas, R. Vazquez-Delgado, J. Salvador-Carlos, E. Beltran-Partida, R. Salinas-Martinez, N. Cheng and M. Curiel-Alvarez, Materials, 14, 3326 (2021); https://doi.org/10.3390/ma14123326
  91. M. Ben Harb, S. Abubshait, N. Etteyeb, M. Kamoun and A. Dhouib, Arab. J. Chem., 13, 4846 (2020); https://doi.org/10.1016/j.arabjc.2020.01.016
  92. D.G. Eyu, H. Esah, C. Chukwuekezie, J. Idris and I. Mohammed, APRN J. Eng. Appl. Sci., 8, 326 (2013).
  93. K. Subbiah, H.-S. Lee, S. Mandal and T. Park, ACS Appl. Mater. Interfaces, 13, 43676 (2021); https://doi.org/10.1021/acsami.1c11994
  94. A. Lame (Galo), E. Kokalari (Teli) and A. Jano, Asian J. Chem., 25, 4017 (2013); https://doi.org/10.14233/ajchem.2013.13892
  95. C. Lisha, M. Rajalingam and S. George, Int. J. Eng. Sci. Invent. Res. Develop., 3, 687 (2017).
  96. N.K. Brixi, L. Sail and A. Bezzar, J. Adhes. Sci. Technol., 36, 1176 (2022); https://doi.org/10.1080/01694243.2021.1962090
  97. T. Ramesh, D.S. Chauhan and M.A. Quraishi, Int. J. Corros. Scale Inhib., 10, 618 (2021); https://doi.org/10.17675/2305-6894-2021-10-2-9
  98. I. Pradipta, D. Kong and J.T. Ban Lee, IOP Conf. Series Mater. Sci. Eng., 431, 042013 (2018); https://doi.org/10.1088/1757-899X/431/4/042013
  99. M.A. Quraishi, V. Kumar, B.N. Singh and S.K. Singh, J. Mater. Environ. Sci., 10, 1001 (2012).
  100. S.A. Asipita, M. Ismail, M.Z.A. Majid, Z.A. Majid, C.S. Abdullah and J. Mirza, J. Clean. Prod., 67, 139 (2014); https://doi.org/10.1016/j.jclepro.2013.12.033
  101. C. Kennedy, F.O.P. Kpae and T.A. Nadum, Int. J. Sci. Eng. Res., 9, 1590 (2018).
  102. Y. Cao, D. Zheng, S. Dong, F. Zhang, J. Lin, C. Wang and C. Lin, J. Electrochem. Soc., 166, C3106 (2019); https://doi.org/10.1149/2.0141911jes
  103. V. Saraswathy, S. Muralidharan, R.M. Kalyanasundaram, K. Thangavel and S. Srinivasan, Cement Concr. Res., 31, 789 (2001); https://doi.org/10.1016/S0008-8846(01)00468-9
  104. B. Yi, J. Wang, L. Feng, Y. Song, J. Liu and H. Shu, Adv. Civ. Eng., 2021, 6655080 (2021); https://doi.org/10.1155/2021/6655080
  105. Z. Liu, L. Yu and Q. Li, J. Wuhan Univ. Technol.-Mater. Sci. Educ., 30, 325 (2015); https://doi.org/10.1007/s11595-015-1148-z
  106. H.Z. Lopez-Calvo, P. Montes-Garcia, E.M. Alonso-Guzmán, W. Martinez-Molina, T.W. Bremner and M.D. Thomas, Can. J. Civ. Eng., 44, 918 (2017); https://doi.org/10.1139/cjce-2016-0237
  107. M. A. Qi, C.A.I. Jingshun, M.U. Song, Z. Xiaocheng, L. Kai, L. Jianzhong and L. Jiaping, J. Chin. Soc. Corros. Protect., 41, 659 (2021).
Read More
Author biographies is not available.
Download
PDF
Statistic
Read Counter : 3 Download : 0