Effect of Sodium Borohydride on Microwave Assisted Reductive Cleaning of Dyed Polyester Fabrics

B. Yesim Büyükakinci; Nihal Sökmen; Büsra Bayender

doi:10.14233/ajchem.2016.20114

Issue

Vol. 28 No. 12 (2016): Vol 28 Issue 12

Issue Published : September 1, 2016

This work is licensed under a Creative Commons Attribution 4.0 International License.

Effect of Sodium Borohydride on Microwave Assisted Reductive Cleaning of Dyed Polyester Fabrics

https://doi.org/10.14233/ajchem.2016.20114

B. Yesim Büyükakinci

Department of Textile Engineering, Faculty of Engineering, Istanbul Aydin University, Istanbul, Turkey

Nihal Sökmen

Department of Textile Engineering, Faculty of Technology, Marmara University, Istanbul, Turkey

Büsra Bayender

Department of Textile Engineering, Faculty of Engineering, Istanbul Aydin University, Istanbul, Turkey

Corresponding Author(s) : B. Yesim Büyükakinci

byesimb2@gmail.com

Asian Journal of Chemistry, Vol. 28 No. 12 (2016): Vol 28 Issue 12
Article Published : September 2, 2016

Abstract

In this study, after dyeing polyester fabrics with disperse dyes, reductive cleaning process was applied using two different reduction agents, sodium dithionite (Na₂S₂O₄) and sodium borohydride (NaBH₄) and two different methods (conventional method and microwave irradiation). Results compared in terms of CIELab values and washing fastness properties of dyed samples. It was observed that the K/S values of the cleaned samples using NaBH₄ were better than those using Na₂S₂O₄. As a result of combined use of NaBH₄, with microwave energy were also advantageous in terms of cost, energy consumption, time and chemical saving.

Keywords

Polyester Reductive Cleaning Microwave irradiation Sodium borohydride Sodium dithionite

Büyükakinci, B. Y., Sökmen, N., & Bayender, B. (2016). Effect of Sodium Borohydride on Microwave Assisted Reductive Cleaning of Dyed Polyester Fabrics. Asian Journal of Chemistry, 28(12), 2752–2754. https://doi.org/10.14233/ajchem.2016.20114

Download Citation

References

M. Bozic and V. Kokol, Dyes Pigments, 76, 299 (2008); doi:10.1016/j.dyepig.2006.05.041.
A. Roessler, New Electrochemical Methods for the Reduction of Vat Dyes, Dissertation ETH No. 15120, Zurich (2003).
J.A. Delgado, C. Claver, S. Castillon, D. Curulla-Ferre, V.V. Ordomsky and C. Godard, Appl. Catal. A, 513, 39 (2016); doi:10.1016/j.apcata.2015.12.019.
S. Piña Jr., D.M. Cedillo, C. Tamez, N. Izquierdo, J.G. Parsons and J.J. Gutierrez, Tetrahedron Lett., 55, 5468 (2014).. doi:10.1016/j.tetlet.2014.08.0684
H. Alinezhad, M. Tajbakhsh and N. Hamidi, Turk. J. Chem., 34, 307 (2010).
I. Dincer, C.O. Colpan, O. Kizilkan and M.A. Ezan, Progress in Clean Energy, Novel Systems and Applications, Springer, vol. 2 (2015).
D. Hua, Y. Hanxi, A. Xinping and C. Chuansin, Int. J. Hydrogen Energy, 28, 1095 (2003); doi:10.1016/S0360-3199(02)00235-5.
N. Meksi, M. Kechida and F. Mhenni, Chem. Eng. J., 131, 187 (2007); doi:10.1016/j.cej.2007.01.001.
J. Yao, C. Dou, S. Wei and M. Zheng, Coloration Technol., 131, 379 (2015); doi:10.1111/cote.12168.
D. Yilmazer and M. Kanik, J. Eng. Fibers Fabrics, 4, 45 (2009).
A. Ouchi, T. Obata, H. Sakai and M. Sakuragi, Green Chem., 3, 221 (2001); doi:10.1039/b104429j.
K. Haggag, A. Ragheb, S.H. Nassar, M. Hashem, H. El-Sayed and I. Abd El-Thalouth, Microwave Irradiationand its Application in Textile Industries, Science Publishing Group, ISBN: 978-1-940366-04-3 (2014).
M.J. Kale and N.V. Bhat, Coloration Technol., 127, 365 (2011); doi:10.1111/j.1478-4408.2011.00332.x.
M. Hashem, M.A. Taleb, F.N. El-Shall and K. Haggag, Carbohydr. Polym., 103, 385 (2014); doi:10.1016/j.carbpol.2013.11.064.
B.Y. Buyukakinci, N. Sokmen and E. Oner, Industria Textila, 65, 228 (2014).
E. Oner, B.Y. Buyukakinci and N. Sokmen, Coloration Technol., 129, 125 (2013); doi:10.1111/cote.12014.
M. Montazer and F. Alibakhshi, 9th Asian Textile Conference, Taiwan, 28-30 June (2007).
H. Sun, L. Lin, X. Jiang and X. Bai, Pigment Resin Technol., 34, 190 (2005); doi:10.1108/03699420510609079.
S.B. Vukusic, D. Katovic and C. Schramm, Text. Res. J., 73, 733 (2003); doi:10.1177/004051750307300812.
R. Purwar and M. Joshi, AATCC Rev., 5, 40 (2005).
M.G.M. Fouda, A. El Shafei, S. Sharaf and A. Hebeish, Carbohydr. Polym., 77, 651 (2009); doi:10.1016/j.carbpol.2009.02.017.
D. Katovic, B.S. Vukusic and F.S. Grgac, Tekstil, 54, 319 (2005).
N.M. Mahmoodi, F. Moghimi, M. Arami and F. Mazaheri, Fibers Polymers, 11, 234 (2010); doi:10.1007/s12221-010-0234-2.
M. Tsukada, S. Islam, T. Arai, A. Boschi and G .Freddi, AUTEX Res. J., 5, 40 (2005).
O.A. Hakeim, S.H. Nassar and K. Haggag, Indian J. Fibre Textile Res., 28, 216 (2003).
N.V. Bhat, M.J. Kale and A.V. Gore, J. Eng. Fibers Fabrics, 4, 1 (2009).
B. Neral, S.S. Turk and R. Schneider, Tekstil, 56, 358 (2007).
A. Ozerdem, I. Tarakcioglu and A. Ozguney, Tekstilve Konfeksiyon, 18, 289 (2008).

References

M. Bozic and V. Kokol, Dyes Pigments, 76, 299 (2008); doi:10.1016/j.dyepig.2006.05.041.

A. Roessler, New Electrochemical Methods for the Reduction of Vat Dyes, Dissertation ETH No. 15120, Zurich (2003).

J.A. Delgado, C. Claver, S. Castillon, D. Curulla-Ferre, V.V. Ordomsky and C. Godard, Appl. Catal. A, 513, 39 (2016); doi:10.1016/j.apcata.2015.12.019.

S. Piña Jr., D.M. Cedillo, C. Tamez, N. Izquierdo, J.G. Parsons and J.J. Gutierrez, Tetrahedron Lett., 55, 5468 (2014).. doi:10.1016/j.tetlet.2014.08.0684

H. Alinezhad, M. Tajbakhsh and N. Hamidi, Turk. J. Chem., 34, 307 (2010).

I. Dincer, C.O. Colpan, O. Kizilkan and M.A. Ezan, Progress in Clean Energy, Novel Systems and Applications, Springer, vol. 2 (2015).

D. Hua, Y. Hanxi, A. Xinping and C. Chuansin, Int. J. Hydrogen Energy, 28, 1095 (2003); doi:10.1016/S0360-3199(02)00235-5.

N. Meksi, M. Kechida and F. Mhenni, Chem. Eng. J., 131, 187 (2007); doi:10.1016/j.cej.2007.01.001.

J. Yao, C. Dou, S. Wei and M. Zheng, Coloration Technol., 131, 379 (2015); doi:10.1111/cote.12168.

D. Yilmazer and M. Kanik, J. Eng. Fibers Fabrics, 4, 45 (2009).

A. Ouchi, T. Obata, H. Sakai and M. Sakuragi, Green Chem., 3, 221 (2001); doi:10.1039/b104429j.

K. Haggag, A. Ragheb, S.H. Nassar, M. Hashem, H. El-Sayed and I. Abd El-Thalouth, Microwave Irradiationand its Application in Textile Industries, Science Publishing Group, ISBN: 978-1-940366-04-3 (2014).

M.J. Kale and N.V. Bhat, Coloration Technol., 127, 365 (2011); doi:10.1111/j.1478-4408.2011.00332.x.

M. Hashem, M.A. Taleb, F.N. El-Shall and K. Haggag, Carbohydr. Polym., 103, 385 (2014); doi:10.1016/j.carbpol.2013.11.064.

B.Y. Buyukakinci, N. Sokmen and E. Oner, Industria Textila, 65, 228 (2014).

E. Oner, B.Y. Buyukakinci and N. Sokmen, Coloration Technol., 129, 125 (2013); doi:10.1111/cote.12014.

M. Montazer and F. Alibakhshi, 9th Asian Textile Conference, Taiwan, 28-30 June (2007).

H. Sun, L. Lin, X. Jiang and X. Bai, Pigment Resin Technol., 34, 190 (2005); doi:10.1108/03699420510609079.

S.B. Vukusic, D. Katovic and C. Schramm, Text. Res. J., 73, 733 (2003); doi:10.1177/004051750307300812.

R. Purwar and M. Joshi, AATCC Rev., 5, 40 (2005).

M.G.M. Fouda, A. El Shafei, S. Sharaf and A. Hebeish, Carbohydr. Polym., 77, 651 (2009); doi:10.1016/j.carbpol.2009.02.017.

D. Katovic, B.S. Vukusic and F.S. Grgac, Tekstil, 54, 319 (2005).

N.M. Mahmoodi, F. Moghimi, M. Arami and F. Mazaheri, Fibers Polymers, 11, 234 (2010); doi:10.1007/s12221-010-0234-2.

M. Tsukada, S. Islam, T. Arai, A. Boschi and G .Freddi, AUTEX Res. J., 5, 40 (2005).

O.A. Hakeim, S.H. Nassar and K. Haggag, Indian J. Fibre Textile Res., 28, 216 (2003).

N.V. Bhat, M.J. Kale and A.V. Gore, J. Eng. Fibers Fabrics, 4, 1 (2009).

B. Neral, S.S. Turk and R. Schneider, Tekstil, 56, 358 (2007).

A. Ozerdem, I. Tarakcioglu and A. Ozguney, Tekstilve Konfeksiyon, 18, 289 (2008).

Issue

Vol. 28 No. 12 (2016): Vol 28 Issue 12

Effect of Sodium Borohydride on Microwave Assisted Reductive Cleaning of Dyed Polyester Fabrics

Corresponding Author(s) : B. Yesim Büyükakinci

Abstract

Keywords

Full Article

Download Citation

References

Table Of Contents